Optimasi dan Pemodelan Proses Recover Flavor Dari Limbah Cair Industri Pengolahan Rajungan Dengan Reverse Osmosis
Abstract
The waste water of blue crab pasteurization has potential in environmental pollution. It contained TSS of 206.5mg.1-1, BOD 7,092.6mg.1-1 and COD of 51,000mg.1-1. on the other hand, it also contains an interesting flavor compound, which composed of 0.23% non protein nitrogen and 17 amino acids where the highest was glutamic acid one. In this study, pre-filtration step using filter size 0.3 µ followed by reverse osmosis has been used to reduce these pollutions load and flavor compound recovery. During pre-filtration steps, TSS was reduced to 74.8% so turbidity decrased reased until 31%. After reverse osmosis process, BOD, and COD decreased more than 99%, and there was no amino acids detected in permeate stream. Factors that affect performance of reverse osmosis were transmembrane pressure, temperature and pH. The higher transmembrane pressure, temperature and pH resulted the higher the flux permeate. The use of higher temperature make flux increasing, eventually increasing transmembrane pressure make the flux increased only at transmembrane pressure less than 716 kPa. The protein rejection was influenced unsignifanctly by transmembrane pressure, temperature and pH. During concentrating flux declined exponentially by time function. At concentration factor 2.75 resulted 79% and 12% of increasing protein and NPN, respectively. The amino acids content can be increased 2−23 times of the origin. Even arginin and sistin, the amino acids that were undetectable initially, but they can bedetected at concentration of 0.0360 and 0.0250 (w/v) respectively at the end of the process. Hidrolysis and fermentation process can increase the amino acid content 31−45 times.Downloads
References
[AOAC] Association of Official Analytical Chemist. 1995. Official Methods of Analysis. Washington DC.
Balakrishnan, M., Dua, M., Bhagat, J.J. 2000. Effect of Operating Parameters on Sugarcane Juice Ultrafiltration: Results of A Field Experience. Separation and Purification Technology 19:209−220.
Box, G.E.P., Hunter, H.G., Hunter, J.S. 1978. Statistical for Experimenters: An Introduction to Design, Data Analysis, and Model Building. John Wiley & Sons, Inc. Canada.
Bradford, M.M. 1976. A Rapid and Sensitive Method for the Quantization of Microgram Quantities of Protein Utilizing the Principle of Protein-Dye Binding. Analyt. Biochem. 72: 248–254.
Carawan, R.E. 1991. Plant Waste Management Guidelines: Aquatic Fisheries Product. Food and EnvSironment. http://www.p2pays.org/ref/02/011796.pdf [ 13 Maret 2006]
Cheryan, M. 1998. Ultrafiltration and Microfiltration Handbook. Technomic. Publishing. New Holland Avenue. 527 pp.
Chiang, B.H., Cheryan, M. 1986. Ultrafiltration of Skim Milk in Hollowfibers. J. Food Sci 51 (2): 340−344.
Cho, C.W., Lee, D.Y., Kim, C.W. 2003. Concentration and Purification of Soluble Pectin from Mandarin Peels Using Crossflow Microfiltration System. Carbohydrate Polymer 54:21−26.
Cros, S., Lignot, B., Bourseau, P., Jaouen, P., Prost, C. 2006. Desalination of Mussel Cooking Juices by Electrodialysis on Aroma Profile. J. Food Eng. 69 (425−436).
Dornier, M., Decloux, M., Lebert, A., Trystram, G. 1994. Use of Experimental Design to Establish Optimal Cross Flow Filtration Condition: Application to Raw Cane Sugar Clarification. J Food Process Eng 17:73−92.
Driscoll, P.E. 1990. Waste Minimization and Product Recovery in Crab Meat Processing Industry. http://www.p2pays.org [ 13 Maret 2006]
Eakin, DE, RP Singh, GO Kohler, K Knuckles. 1978. Alfalfa Protein Fractionation by Ultrafiltration. J Food Sci. 43:544−552.
Gould, C.K., Harrold, S.J., Weitnauer, W.K. 2004. A Practical Approach to Controlling The Fouling of Ultrafiltration Membranes: A Case Study of the Successful Development of A Commercial Soy Protein Application. http//:www.osmonics. com. [25 Februari 2004].
Hartati, F.K., Susanto, T., Rakhmadiono, S., Adi, S.L. 2002. Faktor-Faktor yang Berpengaruh terhadap Tahap Deproteinasi Menggunakan Enzim Protease Dalam Pembuatan Kitin dari Cangkang Rajungan (Portunus pelagicus). Biosain 2: 68−77.
Hue, M.S., Kim, J.S., dan Shahidi, F. 2003. Component and Nutritional Quality of Shrimp Processing By Product. Food Chem. 82:235−242.
Islam, M.S., Khan, S., Tanaka, M. 2004. Waste Loading in Shrimp and Fish Processing Effluents: Potential Source of Hazards to The Coastal; and Near Shore Environments. Marine Pollution Bulletin 49: 103−110.
Jayarajah, C.N., Lee, C.M. 1988. Extraction and Concentration of Flavoring Agent from Shellfish Waste. Annual meeting of institute technology. Juni 19−22.
Jayarajah, C.N., Lee, C.M. 1999. Ultrafiltration/Reverse Osmosis Concentration of Lobster Extract. J. Food Sci. 64 (1):93−98.
Je, J.Y., Park, P.J., Jung, W.K., Kim, S.K. 2005. Amino Acid Changes in Fermented Oyster (Crassostrea Gigas) Sauce with Different Fermentation Periods. Food Chem. 91: 15−18.
Jesus, D.F., Leite, M.F., Silva, L.F.M., Modesta, R.D., Matta, V.M., Cabral, L.M.C. 2007. Orange (Citrus Sinensis) Juice Concentration by Reverse Osmosis. J. Food Eng. 81:287–291.
Kane, L.R., Braddock, J., Sims, C.A., Matthews, R.F. 1995. Lemon Juice Aroma Concentration by Reverse Osmosis. J. Food. Sci. 60 (190−194).
Kessler, H.G. 1986. Energy Aspects of Food Concentration. Didalam: Maccarthy D, Editor. Concentration and Drying of Foods. Elsevier Applied Science Publisher. London and New York; hlm147−163.
Kirk, D.E., Montgomery, M.W., Kortekaas. 1983. Clarification of Pear Juice by Hollow Fiber Ultrafiltration. J Food Sci 48:1663−1666.
Kranawetter, H., Liebminger, A., Samhaber, W.M. 2005. Comparison between Evaporation and Reverse Osmosis Process for Concentrating Aromatic Juices Done with Passion Fruit as An Example. Institute of Process Technology. Austria. 5 hal.
Kumar, N.S.K., Yea, M.K., Cheryan, M. 2003. Soy Protein Concentrates by Ultrafiltration. J. Food. Sci. 7(68):2278−2283.
Kumar, N.S.K., Yea, M.K., Cheryan, M. 2004. Ultrafiltration of Soy Protein Concentrate: Performance and Modeling F Spiral and Tubular Polymeric Modules. J Membrane Sci 244:234−242.
Kuo, W.S., Chiang, B.H. 1987. Recovery of Glutamic Acid from Fermentation Broth by Membrane Processing. J. Food Sci. 52 (1401−1404).
Lin, T.M., Park, J.W., Morrissey, M.T. 1995. Recovery Protein and Reconditioned Water from Surimi Processing Waste. J.Food Sci. 60:(1): 4−9.
Masciola, D.A., Viadero, R.C.Jr., Reed, B.E. 2001. Tubular Ultrafiltration Flux Prediction for Oil-in-Water Emulsions: Analysis of Series Resistances. J Membrane Sci 184:197−208.
Mohammadi, T., Pak, A., Karbassian, M., Golshan, M. 2004. Effect of Operating Conditions on Microfiltration of An Oil-Water Emulsion by A Kaolin Membrane. Desalination 168:201−205.
Montgomery, D.C. 2001. Design and Analysis of Experiments. John Wiley & Sons.Inc. New york.
Olle, D., Baron, A., Lozano, Y.F., Sznaper, C., Baumes, R., Bayonove, C., Brillouete, J.M. 1997. Microfiltration and Reverse Osmosis Affect Rocovery of Mango Puree Flavor Compound. J. Food. Sci. 62 (1116−1119).
Patil, G., Raghavara, K.S.M.S. 2007. Integrated Membrane Process for the Concentration Of Anthocyanin. J. Food. Eng. 78: 1233–1239.
Shiau, C.Y., Chai, T. 1990. Characterization of Oysters Shucking Liquid Wastes and Their Utilization as Oyster Soup. J. Food Sci. 55:374−378.
Shiau, C.Y., Chai, T. 1999. Protein Recovered from Oyster Wash Water Ultrafiltration and Their Utilization as Oyster Sauce Through Fermentation. Journal of Marine Science and Technology. 7:110−116.
Simon, A., Vandanjon, L., Levesque, G., Bourseau, P. 2002. Concentration and Desalination of Fish Gelatin by Ultrafiltration and Continous Diafiltraion Processes. Desalination 144: 313−318.
Subramanian, R., Raghavarao, K.S.M.S., Nakajima, M. 2003. Application of Dense Membrane Theory for Differential Permeation of Vegetable Oil Constituents. J. Food Eng. 60:249−256.
Uju, H.L., Suprihatin, P., Suryadarma, N.E. 2008. Karakteristik Fouling dan Polarisasi Konsentrasi pada Proses Pemurnian dan Pemekatan Karaginan dengan Membran Mikrofiltrasi. J. Tek. Ind. Pert 18(1):34−40.
Uju, N.R., B. Ibrahim. 2004. Pengaruh Frekuensi Pencucian pada Surimi terhadap Mutu Bakso Ikan Jangilus (Isthiophorus spp). Buletin Teknologi Hasil Perikanan 7(2) :1−10.
Uju. 2006. Kajian Pemurnian dan Pengkonsentrasian Karaginan dengan Membran Mikrofiltrasi. Thesis Sekolah Pasca sarjana. Institut Pertanian Bogor.
Uju. 2007. Optimasi Proses Mikrofiltrasi pada Pembuatan Refine Carrageenan. Prosiding Seminar Perikanan Nasional UGM.
[UNEP] United Nations Environment Programme. 2006. Cleaner Production Assesment in Fish Processing. http:www.agrifood-forum.net/publications/guide/fish guide.zip. html [15 Maret 2006]Vandanjon L, Cros S, Jaouen P, Qomuemeneur F, Bourseau P. 2002. Recovery by nanofiltration and reverse osmosis of marine flavours from seafood cooking waters. Desalination 144: (379−385)
Venugopal, V. 2006. Post harvest Quality Changes and Safety Hazard. dalam Seafood Processing: Adding Value Through Quick Freezing, Retortable Packaging, and Cook-Chilling. Editor V. Venugopal. Taylor & Francis. London. Hal 23−60.
Vernhet, A., Cartalade, D., Moutounet, M. 2003. Contribution to the Understanding of Fouling Build-up During Microfiltration of Wines. J Membr Sci 21:1357–370.
Voigt, M.N., Osborne, R., Hall, D.E. 1990. Profile test Active Components in Crab Products/ by-Products and in Cod Surimi. Dalam Advance in Fisheries Technology and Biotechnology for Increase Profitability. Editor: M.N. Voigt dan J.R. Botta. Technonmic Publishing. Lancaster.
Yean, S.W. 1994. Effect of Washing Treatment on the Quality of Nemipterus tolu Fish Balls. Asean Food Journal9: 111−115.
This journal is published under the terms of the Creative Commons Attribution-NonCommercial 4.0 International License. Authors who publish with this journal agree to the following terms: Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution-NonCommercial 4.0 International License. Attribution — You must give appropriate credit, provide a link to the license, and indicate if changes were made. You may do so in any reasonable manner, but not in any way that suggests the licensor endorses you or your use. NonCommercial — You may not use the material for commercial purposes.
View JIPI StatsCounter
